I used to make this from scratch. The pasta all the way through...This time around I got a jump start by paying $3 for a pound of fresh egg pasta sheets at the farmers' market. Fantastic return on $3. You still need to run those sheets through a pasta machine a few times to achieve the most thin and delicate sheets of pasta possible - but starting from pre-bought was a bit of a revelation for me, and a big timesaver. If you don't have a pasta machine (they are actually quite affordable!), try a rolling pin - not quite the same, but will help thin out the sheets....It also dawned on me that I might be able to get away with skipping the pre-boil step in this recipe altogether and dial up the amount of sauce a bit (though I've never tried it this way) - I suspect you might be sacrificing some of the tenderness of the noodles to save the time it takes to boil and drain...just a thought. Make sure the pasta sheets you buy are fresh and moist. Proper seasoning is important throughout this recipe, if you undersalt it is going to taste flat and the flavors won't pop - the right amount of salt brings the pasta forward and focuses the tomato and lemon flavors in the sauce. Ingredients 1 pound fresh egg pasta sheets (or make some from scratch) butter to prep baking dish 3 tablespoons extra-virgin olive oil 1 teaspoon fine grain sea salt 1 teaspoon crushed red pepper flakes 1 clove garlic chopped 1 (28-oz) can crushed organic tomatoes zest From one lemon 3 4-ounce balls of fresh mozzarella torn up into little pieces handful of slivered basil optional freshly grated Parmesan optional

Instructions
Preheat your oven to 375. Start by clearing off every flat space in your kitchen, you are going to need and use all of it.
Make your sauce: Place the olive oil, salt, pepper flakes, and garlic in a pan. Dial the heat up and saute for a minute or two. Add the tomatoes and slowly bring to a simmer as well. Remove from heat, stir in the lemon zest and taste for seasoning. Add more salt if needed. Set aside.

Fill your biggest pot full of water and bring to a boil.

Lavishly butter a deep, square baking dish. The one I use is 9x9 and 2 1/2-inches deep.
Thin out your pasta using a pasta machine. Start by cutting the big sheets into 2-inch(ish) wide ribbons. This means making 2 cuts along the sheets. This should yield you about 12 2-foot strips. Run them through the pasta machine. I go to the 8 setting, one shy of the very thinnest setting. The sheets should almost be translucent. Cut the strips into manageable rectangles roughly 4-inches in length.

Pre-cook the pasta: Fill a large bowl with cold water and a few glugs of olive oil. Place a large flour sack or cotton dish towel across one of your counters. Salt your pot of boiling water generously. Ok, now you are ready to boil off your pasta. Believe it or not, you are on the home stretch. Place a handful of the pasta rectangles into the boiling water to cook (I've found I can get away with about 20 at a time), fish them out (I use a pasta claw) after just 15-20 seconds, don't over cook. Transfer them immediately to the cold olive-oil water for a quick swim and cool-off. Remove from the cold water bath and place flat and neat on the cotton towel. It is ok for them to overlap, I don't have a problem with the sheets sticking typically. Repeat until all your pasta is boiled.

Pull it all together. Ladle a bit of the sauce into the bottom of the prepared baking dish. Cover the bottom with a layer of pasta sheets. Now a thin layer of sauce, and a bit of cheese. Go for another layer of pasta, then sauce, then pasta again, then sauce and cheese. Keep going until you've used up all the sauce and pasta. You want to finish with a layer of pasta. Top with the last of the sauce and the very last of the cheese so you have a nice cheesy top.

Bake until everything is melted and fragrant, 35 minutes or so. Let it sit for 10 minutes before serving, so everything has a chance to set up a bit. Dust with parmesan and a bit of slivered basil.

This recipe published with BigOven, and can be imported instantly by BigOven users viewing this page. Download your free trial at www.bigoven.com.


Yields: 0
     http://www.101cookbooks.com

notes: 

Cuisine:   Italian

Main Ingredient: